94 awd safari how hard to replace power steering lines

ANYTHING TO DO WITH MAKING YOUR VAN MOVE EXCEPT FOR THE ENGINE ITSELF.
Post Reply

Topic author
ron02032
I am merely driving my van
I am merely driving my van
Posts: 4
Joined: Thu Jul 10, 2008 11:50 am
Location: Burlington, Ontario

94 awd safari how hard to replace power steering lines

Post by ron02032 »

Any info on how hard it will be to change p/s lines on a 94 safari? It will have to be done in my driveway. I had a look at it today and it sure doesn't look as though there is much room there. Any hints on how to make it easier? Any advice will be greatly appreciated. If the weather changes and i can't do it in the driveway, is it ok to drive the van a short distance (approx 1/2 mile) to a garage? It won't hold any p/s fluid at all. It has the hydro boost, if it matters.
Thanks in advance,
Ron

Moreforles
I sleep in my van
Posts: 354
Joined: Fri Feb 22, 2008 8:35 am
Location: Cleveland, Ohio

Re: 94 awd safari how hard to replace power steering lines

Post by Moreforles »

ron02032 wrote:Any info on how hard it will be to change p/s lines on a 94 safari? It will have to be done in my driveway. I had a look at it today and it sure doesn't look as though there is much room there. Any hints on how to make it easier? Any advice will be greatly appreciated. If the weather changes and i can't do it in the driveway, is it ok to drive the van a short distance (approx 1/2 mile) to a garage? It won't hold any p/s fluid at all. It has the hydro boost, if it matters.
Thanks in advance,
Ron
with the hydraboost off (if its equipt with one) battery out.... leaves a few more inches to rooms..... but its very tight.
2000 Astro, passenger van. Converted into a cargo van, used for Carpet cleaning (10 lbs of crap, in a 5 lb bag)

rlsllc
I sleep in my van
Posts: 901
Joined: Thu Sep 21, 2006 6:35 pm

Re: 94 awd safari how hard to replace power steering lines

Post by rlsllc »

Remove the upper shroud, fan, and lower shroud. It is almost easy after that, if you're long armed and flexible you may not even have to get under the van. I'm not either one, so I get the lines off of the pump from underneath.

The cooling loop is a bear to get to no matter what, the valence under the bumper has to come off and I think the grill, could be wrong there. Depends on how many lines you are changing.

Lumpy
I finally get the smurf thing
Posts: 149
Joined: Sun May 31, 2009 6:52 pm

Re: 94 awd safari how hard to replace power steering lines

Post by Lumpy »

I don't think my 89 has Hydroboost, whatever that is.
But I've replaced both the low and hi pressure lines
between pump and steering box. Both were done
without removing any fan shrouds, hoses or
anything else. Both done in my driveway
using normal hand tools.

an 18mm flare nut wrench would be a luxury.
Heck, an 18mm open end would be a luxury.
I didn't have either. I used an actual
WalMart branded crescent wrench. A wrench
that is too LONG is a hassle as it doesn't give you
much rotation before you have to get a new "bite"
on the nut.

I primarily worked from beneath the van
with the front wheels on ramps. Lifetime
guaranteed hoses from Checker. Used teflon
plumbers tape on the threaded fittings.
It's tight, it's dirty, but on mine at least,
it's do-able.

Amsoil ATF for PS fluid.

Lumpy

Did you do a lot of those Emergency Broadcast Warnings?
Yes. Had it been an actual emergency I would have hid.

www.LumpyMusic.com

rlsllc
I sleep in my van
Posts: 901
Joined: Thu Sep 21, 2006 6:35 pm

Re: 94 awd safari how hard to replace power steering lines

Post by rlsllc »

The RWD without hydroboost is much more accessable. It may be possible without removing the shroud on the AWD with hydroboost, but it is easier with the shroud removed.
Post Reply