Did some "real" towing with the 'Stro today.


Topic author
overdrive75
I am merely driving my van
I am merely driving my van
Posts: 17
Joined: Sun Mar 06, 2011 4:56 pm
Location: Whitmore Lake, MI

Did some "real" towing with the 'Stro today.

Post by overdrive75 »

It's been a while since I have been on here, I have been busy, sorry for that.

Image

Boat is listed at 3,900 lbs dry, she has a SBC 350 in here and holds 75 gallons of fuel, it was full. Also had some of my stuff on it and both coolers full. So I estimated the boat and trailer somewhere in the 5,500 to 6,000 range as it sits in that picture. My van is AWD and has the 3.42's in it. I just turned on the tow/haul and put her in D3 and rolled. She did really good on the 60 mile round trip. I was 90 here today we were running the AC and the temp gauge never never went north of about 205. I forgot my DashDAQ at home otherwise I would of had trans temps too. She got right up to speed and was stable, I ran here up to 65 mph.

Next question, I don't have and AUX trans cooler, but I do have the 8 wire trailer light harness in the jack area, so does that mean I have the trailer tow package?

Oh yeah I am going to add the firestone ride rites, as my Monroe air shocks wouldn't lift it much once hooked up.
2003 Majestic Conversion AWD. Family Truckster. Now if I can just get it to tow the boat I would be all set.
User avatar

CaptSquid
I plan to be buried in my van
Posts: 1230
Joined: Sun Sep 10, 2006 4:50 am
Location: Billings, MT, 'MERICA!

Re: Did some "real" towing with the 'Stro today.

Post by CaptSquid »

Nice looking boat. You know the old saw about the two happiest days in a boat owner's life -- the day he gets the boat and the day he gets rid of it.

I, too, have the trailer light harness in the jack area, I don't know if I have the towing package, but I have a 350 lb scooter hanging off a Class III/IV receiver. It does give the Stro a nose-up attitude, so I'll be looking into helper springs on the back.
Mike, Billings, MT, 'MERICA!
92 Safari SLE w/Z Motor (sold to a good home)
98 AWD Stro LS
93 Suburban Silverado 4x4

Look for the MISSING Alien in the Right Seat. AL, PHONE HOME!!!

ImageImage
Image

astroturf
ASV Supporter
ASV Supporter
Posts: 1658
Joined: Wed Sep 09, 2009 6:25 pm

Re: Did some "real" towing with the 'Stro today.

Post by astroturf »

What a load !!!

The towing package (as far as I know) was the 8th wire to the back.

Everybody else got only 7.

The trans cooler (stock & towing) is the same.

Jim
User avatar

arlon
I finally get the smurf thing
Posts: 164
Joined: Wed Dec 28, 2011 8:56 am
Location: Midland Texas
Contact:

Re: Did some "real" towing with the 'Stro today.

Post by arlon »

My van has a towing package. It has 3.73 gears and a g80 locker. Seems like the taller gears might have been part of the towing package. Receiver hitch may have been part of the deal too. Also has electric brake connections.. And I'm a little concerned about towing a 2500lb Casita..
2004 AWD Astro 2" lift, overnight-able
2003 Dodge/Cummins Quad cab
2006 Nissan X-terra MT
1985 LTD LX 5.0 HO
Plus wife's and kid's cars to take care of...

astroturf
ASV Supporter
ASV Supporter
Posts: 1658
Joined: Wed Sep 09, 2009 6:25 pm

Re: Did some "real" towing with the 'Stro today.

Post by astroturf »

arlon wrote:My van has a towing package. It has 3.73 gears and a g80 locker. Seems like the taller gears might have been part of the towing package. Receiver hitch may have been part of the deal too. Also has electric brake connections.. And I'm a little concerned about towing a 2500lb Casita..
Good Points...

I missed the Hitch, Most important part by the way, well without it, we know how that ends up.

Good Save, Thanks, Jim

Topic author
overdrive75
I am merely driving my van
I am merely driving my van
Posts: 17
Joined: Sun Mar 06, 2011 4:56 pm
Location: Whitmore Lake, MI

Re: Did some "real" towing with the 'Stro today.

Post by overdrive75 »

Point taken about the trans cooler. So I have the 8 wire harness in the rear. I have the orange and blue up front. However I have the 3.42 gears, so is it possible that the trailer tow package was something other than the axle being the 3.73. Maybe wiring, and different fan clutch or some thing like that? Anyhow the van towed, well actually really well, however I did not let it go to 4th I locked it in D3. Normally we pull the boat with our '02 2500HD, however with one kid and the second due here in about a month I thought I would give the van a try, after all it has more kid friendly comforts in it then the pickup and rides much better too. So based on yesterday, add the trans cooler throw some ride rites on the rear, and it looks like we have a second tow vehicle. Now we can take the travel trailer and the boat up north and vacation.

Thanks for the complement on this boat, by the way I am actually happy with this one, so I don't know how much that statement applies, it.
2003 Majestic Conversion AWD. Family Truckster. Now if I can just get it to tow the boat I would be all set.
User avatar

1Gary
I have my van tatooed on my cheeks
Posts: 2743
Joined: Wed Oct 07, 2009 4:18 am

Re: Did some "real" towing with the 'Stro today.

Post by 1Gary »

Yeah without a aftermarket trans cooler your trans isn't going to show you much love very soon. :yikes:
1979 Malibu drag race only car
1999 Sonoma 4.3 5 speed-Rufus
1989 Astro-Ole Yellar cancelled-still selling off parts
1985 Astro-shop van R.I.P. my friend
1994 Astro LT RWD W4.3 rod knock RIP
1982 Winnebago single rear wheel-Chevy 350 Scraped 1/28/13-broken dreams......


Rochester,NY

LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

Re: Did some "real" towing with the 'Stro today.

Post by LiftedAWDAstro »

The "towing package" only consisted of the brake controller wiring and a hitch in the newer vans. 3.42 gears were standard and if you wanted better, you had to order the 3.73's and G80. They were not part of a package. All the vans (96+) got the same fan clutch, trans cooler and engine oil cooler both which are in the radiator and are only good for an empty van. You definitely want an aux trans cooler.
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy

Topic author
overdrive75
I am merely driving my van
I am merely driving my van
Posts: 17
Joined: Sun Mar 06, 2011 4:56 pm
Location: Whitmore Lake, MI

Re: Did some "real" towing with the 'Stro today.

Post by overdrive75 »

LiftedAWDAstro wrote:You definitely want an aux trans cooler.
Ok, I read the how to on the trans cooler install, and I have put on my Cherokee, so no newbie there. However I cannot find the how to on removing the grill on the van. I keep reading about hidden screws? Thanks for the help.
2003 Majestic Conversion AWD. Family Truckster. Now if I can just get it to tow the boat I would be all set.

astroturf
ASV Supporter
ASV Supporter
Posts: 1658
Joined: Wed Sep 09, 2009 6:25 pm

Re: Did some "real" towing with the 'Stro today.

Post by astroturf »

Behind the turn signals.
User avatar

1Gary
I have my van tatooed on my cheeks
Posts: 2743
Joined: Wed Oct 07, 2009 4:18 am

Re: Did some "real" towing with the 'Stro today.

Post by 1Gary »

I suggest you want to zip tie the trans cooler so there is a air space between the cooler and rad.I also suggest to not use those through the rad zip ties because of the potential of vibrations of them creating a rad leak with them rubbing against the tubes of the rad.
1979 Malibu drag race only car
1999 Sonoma 4.3 5 speed-Rufus
1989 Astro-Ole Yellar cancelled-still selling off parts
1985 Astro-shop van R.I.P. my friend
1994 Astro LT RWD W4.3 rod knock RIP
1982 Winnebago single rear wheel-Chevy 350 Scraped 1/28/13-broken dreams......


Rochester,NY

LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

Re: Did some "real" towing with the 'Stro today.

Post by LiftedAWDAstro »

I wouldn't use zip ties at all. Bend up some simple metal brackets to mount the cooler. Gary is right in that you want it spaced away from the a/c condenser.
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy

Topic author
overdrive75
I am merely driving my van
I am merely driving my van
Posts: 17
Joined: Sun Mar 06, 2011 4:56 pm
Location: Whitmore Lake, MI

Re: Did some "real" towing with the 'Stro today.

Post by overdrive75 »

Not going to use zip ties, I am going to brackets. Here are the pieces I am going to install. Thoughts?

Trans cooler: http://www.amazon.com/gp/product/B000C3 ... PDKIKX0DER

Fitting kit: http://www.amazon.com/gp/product/B000EP ... PDKIKX0DER

And trans fluid thermostat, so I can keep my Fuel Economy up in the Michigan winters: http://www.amazon.com/gp/product/B004XO ... PDKIKX0DER

Looking for feed back.
Last edited by overdrive75 on Wed Jun 13, 2012 5:19 pm, edited 1 time in total.
2003 Majestic Conversion AWD. Family Truckster. Now if I can just get it to tow the boat I would be all set.
User avatar

mdmead
ASV Supporter
ASV Supporter
Posts: 2153
Joined: Sun Sep 10, 2006 6:45 pm
Location: Selah, WA
Been thanked: 1 time
Contact:

Re: Did some "real" towing with the 'Stro today.

Post by mdmead »

The link for the trans cooler thermostat is for the fittings kit again. (I want to see the thermostat!) :muhaha:
Matt
Selah, WA
-96 GMC Safari AWD Hi-Top Conversion -->Stalled 5.3L swap & 5" lift
-74 Ford Bronco -->Far from perfect but mine!
-99 V-10 Ford Super Duty Super Cab 4x4 -->Stock with 285 Cooper ATs
-00 Ford Focus Wagon -->The Red Turd
-95 Ford 24' Class C Motorhome -->My big block sleeper
-07 Can-Am Outlander XT -->My yellow 4x4 quad for work & play
-04 Ski Doo REV Summit -->Still several chassis behind!


No new projects until the current ones are done!

Topic author
overdrive75
I am merely driving my van
I am merely driving my van
Posts: 17
Joined: Sun Mar 06, 2011 4:56 pm
Location: Whitmore Lake, MI

Re: Did some "real" towing with the 'Stro today.

Post by overdrive75 »

Thermostat link fixed, sorry.
2003 Majestic Conversion AWD. Family Truckster. Now if I can just get it to tow the boat I would be all set.
Post Reply